Hygrometer Calibration

Hi folks,

As some of you know I just purchased 2 new humidors. I had been using a digital hygrometer in my older 100 count, but it was one that could not be calibrated. I was tired of making mental notes of how high or low the reading was off and decided to get a couple new hygrometers that can be calibrated.

I got 3 HygroSet Super Accurate Digital Hygrometers (the rectangle kind), and tried to calibrate them using the salt test first. After a week of trying and getting massive changes in Rh readings, I then used some of the Boveda calibration kits. I have to tell you these kits make it VERY hard to turn the calibration knob without opening the bag. To my mind it would be better to not open the calibration bag so that the Rh inside wouldn't change every time I made an adjustment. I also waited a full 48hrs before trying to calibrate them.

I have been calibrating them exactly how the paperwork says, and I am still getting reading that are between 4-7% off. I have also read that many others have the same problem with these units. So I am considering biting the bullet and getting a different kind of hygrometer altogether, as well as new calibration kits and start from scratch. Especially since I just started seasoning the new humidors, and have no way to tell whats going on.

These seem to get very good reviews and are also able to be calibrated, do any of you have any experience with them, or have any suggestions on something better. I will need 3 of what ever they are.

The one I am considering getting:
https://www.amazon.com/Cigar-Oasis-C...YK5EWBF9R2D70K

***EDIT-Well apparently these don't get the raving reviews I originally thought, so if you have better options I am all ears. I have been trying to get this sorted out for nearly 3 weeks now.

*Note, I know some of you will possibly be thinking just use the old one until you get this sorted out. I would but my wife thought I wanted her to throw it away, so I'm flying blind with my original humidor (320g 62% Boveda pack), my new foot locker (4-320g 65% Boveda packs) and the one I just started seasoning (4-320g 84% packs)

Thanks, any help would be VERY much appreciated.
Chris

Accurite Hygro ...Amazon $8....I have a dozen of these and they are accurate from 1 to 2%....they have never deviated not 1 % in the last half dozen years I've owned them. All you need is one current good hygro to compare them to.....put em all in one tupperador.....check them readings and you're done. The ones that are more than 2% off take em back and get replacements which is what I did....no salt test, no nonsense or incantations or knob twisting...etc.

I got a couple of the xikar purotemp but honestly I never calibrated them but all my hydrometer are within a couple %from each other so i run with that.

I may test my hydrometer next time they need batteries

I use those round Caliber's and haven't had any problems. Super easy to calibrate and batteries last awhile.

The Accurite hygrometer I also use and love it's cheap and very true. Plus Home Depot sells them and you can easily return if it's off too much Rh. I actually know somebody who retuned 3 till he got one that was perfect!

Question? Are you using a fresh boveda for calibration? I've never had success with the calibration packs. Always grab a fresh boveda close to my preferred Rh and throw in bag with hygro. Has worked every time

Sent from The Cauldron Of Insanity

Quote:

---

Originally Posted by Kidvegas

Question? Are you using a fresh boveda for calibration? I've never had success with the calibration packs. Always grab a fresh boveda close to my preferred Rh and throw in bag with hygro. Has worked every time

---

Same here. I toss a new 65% Boveda pack and the hygrometer(s) in question into a quart mason jar overnight and see what they say in the morning. It's important to keep the temperature constant. Any temp will work but it has to remain steady for the rH to stabilize. A Mason jar works better than a bag IMO, even with a used sealing disk.

Quote:

---

Originally Posted by Kidvegas

I use those round Caliber's and haven't had any problems. Super easy to calibrate and batteries last awhile.

The Accurite hygrometer I also use and love it's cheap and very true. Plus Home Depot sells them and you can easily return if it's off too much Rh. I actually know somebody who retuned 3 till he got one that was perfect!

Question? Are you using a fresh boveda for calibration? I've never had success with the calibration packs. Always grab a fresh boveda close to my preferred Rh and throw in bag with hygro. Has worked every time

Sent from The Cauldron Of Insanity

---

I was going to take one of the new 320gram 65% packs I have and do it that way. I read a few places that calibrating them at lower than 75% will give inaccurate readings, which didn't make sense, since we are monitoring them in that range anyhow.

Maybe I will give that a try before buying different units. I will take 2 of them and put them in a thick ziplock freezer bag and wait 24-36 and see what they read.

Still wouldn't mind some input on quality hygrometers that you guys trust, in the event I can't get these to work right.

Thanks for the help

Hey Chris,

I read in your original post about trying to calibrate the hygro while still in bag. Personally I've never done this. I'll always take it out after about 8 hrs change the numbers up or down then throw back into bag for another 8. Should be dead on but I wouldn't be pissed with a + or - of 1 or 2

Sent from The Cauldron Of Insanity

I recently had to replace my Hydroset II, the calibratable rectangular one.

I picked up this Acurite 00309B at Lowe’s for like $12. Amazon has several similar as low as $8. Pretty sure most of these have the same guts/ sensors.
I like that it tracks high/low for a 24 hour period so I can see if there are fluctuations. Not that I would be concerned if there were unless it was happening all of the time. Also, the large numerals are pleasing for my aging eyes.

https://uploads.tapatalk-cdn.com/201...db35100599.jpg

I verified accuracy with the salt test in a gasket sealed container. It was pretty much dead on at 75% RH. Ziplock type bags aren’t as air/moisture tight as many believe.
This is my salt test set-up. A glass dish (plastic is fine too) With about 1/4 inch salt in the bottom and enough water to moisten all of the salt. There is just barely a skim of water on the top surface.

You don’t need this much salt, but it is more stable that way and reaches equilibrium faster. The increased surface area of the dish helps too.
https://uploads.tapatalk-cdn.com/201...47559e2eeb.jpg

For the adjustable ones, you don’t have to adjust while still in the bag. Just note the difference and turn the dial however many clicks / marks as indicated. It is only adjusting the numeral displayed and not establishing a set-point. IIR, you have to press and hold the calibration button again after turning? Refer to your instructions to be sure.

I think too much stock is placed on the accuracy/ precision of these digital hygrometers. They all are +/- 2% or worse (Not 2% of the reading, but a flat 2%. This is a 4% absolute variance and almost 6% of the reading at 70% RH. We use NIST calibrated hygrometers in the lab at work costing almost $100 or more that are still stated as +/- 2% for humidity. I think most of the price tag is for the NIST sticker and certificate.[emoji6]

Not too much technology in these to vary too much, just the care taken to adjust the trimpot and the consistency of components.



Sent from my iPhone using Tapatalk

A ziploc back with a fresh boveda pak (whatever rH) usually works fine for me.
And I try to leave it for 24 hrs.

I took two of the hygrometers and a new 320gram 65% Boveda pack, and sealed them in a ziplock freezer bag Monday at 6:00 pm.

As of 11pm they both read 65%, I will wait at least the full 24 hours, before making any adjustments if they are needed.

TY!

Am I the only one who chucks a few Bovedas in their tupperdores and trusts them to do their job? Now I feel like I need to buy a hygrometer when I get off work...

I used to have one when I first started in the hobby, and the Bovedas were so reliable that I just never replaced the batteries.

I've also NEVER had to recharge any of my Bovedas, which I find a bit strange. But I think that goes to show you how over humidified cigars come when you buy them online. They essentially recharge my Bovedas for me.

I know hygrometers and monitoring is WAY more important when using actual humidors, BTW. I don't mean to suggest otherwise.

Quote:

---

Originally Posted by CentralTimeSmoke

Am I the only one who chucks a few Bovedas in their tupperdores and trusts them to do their job? Now I feel like I need to buy a hygrometer when I get off work...

---

No you don't. My 5 gallon buck-a-dor doesn't have a hygrometer in it and never has. Hygros really are sorta worthless imo. They're basically a fashion accessory. As long as you have enough Bovedas (and you replace them when they start getting flat) and your cigars are smoking fine, I don't think you need one, not even in a humidor. But... in a wood humidor, you need to be sure you have enough Bovedas to keep up with the loss. So until you figure out how many you need I guess a hygro does have some value.

Getting close to 12:00 pm here and they are both reading 66%. At 6pm, which will be 24 hours, I will look again and see if I need to make any fine adjustments.

Also,
Remember I am in the process of seasoning and stabilizing 2 large humidors, I at least need the hygrometers to know whats going on in them etc...

I understand if you guys trust the Boveda packs, and don't feel a need to use a hygro. I just prefer to play it safe and monitor them so I know if anything starts to go out of wack for whatever reason. As with many things cigars related, a lot of personal preference is involved. So if your happy and your sticks smoke good, do your thing, I say.:stogie:

Quote:

---

Originally Posted by LazyLightning

Getting close to 12:00 pm here and they are both reading 66%. At 6pm, which will be 24 hours, I will look again and see if I need to make any fine adjustments.

---

Probably the air conditioning kicked on. Any time the temperature falls your rh is going to spike until the boveda pack can catch up.

True,
They have been sitting at 70 all night and day, one is reading 66% the other 66-67%. At 24 hours I am going to make an adjustment and wait until morning to make sure they are both at 65%. If so, they will go back in the new humidors so I can get this seasoning show back on the road.

Made a tiny adjustment at the 24hour mark, which was 6pm Tue. evening. They stayed at 70/65% the rest of the evening and were still sitting dead on at 12pm today.
They are now back in the new humidors and the seasoning is back on track.

Appreciate all the help with this one guys, very very much!